Product ID:L/O MIL-L-2104D/46152B SAE 15W-40
MSDS Date:01/09/1989
FSC:9150
NIIN:01-152-4118
MSDS Number: BLPHB

CHEVRON ENVIRONMENTAL HEALTH CENTER INC.

15299 SAN PABLO AVE.
RICHMOND, CA 94804-0054
US

Emergency Phone: 415-233-3737

Info Phone: 415-233-3737

Cage: 0AHD1

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

4054 RICHMOND, CA 94804 US

Telephone: 800-582-3835

Cage: 0AHD1

DISTILLATES, HYDROTREATED HEAVY PARAFFINIC

CAS: 64742-54-7

RTECS: PY8035500

Fraction By Weight: >70%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

ZINC DIALKYLDITHIOPHOSPHATE & ZINC DIARYLDITHIOPHOSPHATE

CAS: 68649-42-3

Fraction By Weight: <30%

LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5G/KG ESTIMATED
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ON RARE OCCASIONS, PROLONGED AND
REPEATED EXPOSURE TO OIL MIST POSES A RISK OF PULMONARY DISEASE
SUCH AS CHRONIC LUNG INFLAMMATION. THIS CONDITION IS USUALLY
ASYMPTOMATIC AS A RESULT OF REPEATED SMALL ASPIRATIONS. SHORTNESS
OF BREATH AND COUGH ARE THE MOST COMMON SYMPTOMS. ASPIRATION MAY
LEAD TO CHEMICAL PNEUMONITIS.
Explanation of Carcinogenicity:IARC HAS DETERMINED THERE IS SUFFICIENT
EVIDENCE FOR THE CARCINOGENICITY IN EXPERIMENTAL ANIMALS OF USED
MOTOR OIL.
Effects of Overexposure:GENERALLY CONSIDERED MINIMALLY IRRITATING TO
THE EYES AND MILDLY IRRITATIONG TO THE SKIN. PROLONGED AND REPEATED
CONTACT MAY RESULT IN VARIOUS SKIN DISORDERS SUCH AS DERMATITIS,
FOLLICULITIS OR OIL AC NE. INHALATION OF VAPOR OR OIL MIST MAYCAUSE
MILD UPPER RESPIRATORY TRACT IRRITATION. SLIGHTLY TOXIC IF
SWALLOWED.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION DEVELOPS. INHALATION: REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYE : IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: MAY ACT AS A
LAXATIVE. DO NOT INDUCE VOMITING. RELATIVELY NON-TOXIC UNLESS
ASPIRATED.

Flash Point Method:COC
Flash Point:447F,231C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.

Spill Release Procedures:CONTAIN SPILL IMMEDIATELY. DO NOT ALLOW SPILL
TO ENTER SEWERS OR WATERCOURSES, REMOVE ALL SOURCES OF IGNITION.
ABSORB WITH APPROPRIATE INERT MATERIAL SUCH AS SAND, CLAY, ETC.
LARGE SPILLS MAY BE PICKE D UP USING VACUUM PUMPS, SHOVELS,
BUCKETS, ETC.

Handling and Storage Precautions:DO NOT TRANSFER TO UNMARKED
CONTAINERS. STORE IN CLOSED CONTAINERS AWAY FROM HEAT, SPARKS, OPEN
FLAME, OR OXIDIZING MATERIALS. COMBUSTIBLE LIQUID.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICL ES THAT CAN NOT BE DECONTAMINATED.

Respiratory Protection:USE NIOSH/MSHA APPROVED AIR-PURIFYING RESPIRATOR
FOR ORGANIC VAPORS AND PARTICULATES OR AN ATMOSPHERE-SUPPLYING
RESPIRATOR IF REQUIRED. PROTECTION IS NOT REQUIRED UNDER NORMAL USE
CONDITIONS.
Ventilation:NO SPECIAL REQUIREMENTS UNDER ORDINARY CONDITIONS OF USE.
MECHANICAL EXHAUST RECOMMENDED IF USED IN ENCLOSED AREA.
Protective Gloves:CHEMICAL RESISTANT GLOVES (NITRILE BEST)
Eye Protection:WEAR CHEMICAL SAFETY GOGGLES
Other Protective Equipment:WEAR PROTECTIVE CLOTHING, APRON AND BOOTS AS
REQUIRED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:MINIMIZE SKIN CONTACT. WASH WITH SOAP AND WATER
BEFORE EATING, DIRNKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
THIS PRODUCT IS CLASSIFIED AS AN OIL UNDER SECTION 311 OF THE CLEAN
WATER ACT. SPILLS ENTERING SURFACE WATERS OR ANY WATER COURSES OR
SEWERS ENTERING/LEADING TO SURFACE WATERS THAT CAUSE A SHEEN MUST
BE REPORTED TO THE NATIONAL RESPONSE CENTER. 800-424-8602

HCC:V6
Spec Gravity:0.88
Viscosity:99.1 CST
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK BROWN LIQUID.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER UNIDENTIFIED
ORGANIC COMPOUNDS MAY BE FORMED UPON COMBUSTION. MAY PRODUCE OXIDES
OF SULFUR.

Waste Disposal Methods:WASTE MAY BE BURNED IN AN APPROVED INCINERATOR
OR DISPOSED OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND
FEDERAL LAWS AND REGULATIONS. RECYCLE IF POSSIBLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.